EMB145短停

CHINA SOUTHERN AIRLINES A/C Type EMB145 机种： A/C Tail No. 飞机号： Maint. Station 维修站： Work Order 工作指令号： Workorder Date 工作指令日期： Print Date 打印日期： JC SEQ No. 顺序号： 中国南方航空公司 General airplane mechanic 机械 Man Hours 工时 Labor 人力 Job Card 工卡号: AIRPLANE 飞机 Elapsed 停场时间 Revision 修订 EM000000600X52A00-1 Interval 间隔 Repeat 重复 Version 版本 Written/Revised By 编写/修订 TRANSIT Station站位 TRANSIT Stringer桁条 Related Card相关工卡 2004-04-01 Manufacturer Card厂家工卡 R1 hedz Reviewed By审核 N/A N/A N/A N/A chensh Zone区域 Access Panel接近盖板 MRS No. MRS号 N/A N/A JC Title 工卡标题 EMB145 TRANSIT MAINTENANCE CHECKLIST EMB145飞机短停维护工作单 00-00-00-600-X52-A00 00-00-00-600-X54-A00 Mech Insp 机械员 检验员 Tools & Equipment 工具和设备： Parts & Material 部件和航材： Not Required 不需 Not Required 不需 Work Content 工作内容： EMB145飞机短停维护工作单 - 机电/电子 1. Set wheel chocks, put fire extinguishers in position. Plug in the ground crew headset. Contact the ______ XXXXX flight crew, and ask them to release the brakes. Install landing gear safety pins if necessary. 挡好轮挡，放好灭火瓶，插上耳机与机组联系松刹车，按需安装起落架安全销。 2. Review the failures report from the logbook and debrief the flight crew for the fault and read out ______ XXXXX related fault messages with EICAS then report them to the leadman for handling. Take action for the failure and sign the log book. 查阅飞机记录本的故障记录，听取机组反映的故障，通过EICAS检查故障信息然后将故障报告领班并处理。处理故障后在记录本上签字。 Aircraft Effectivity飞机适用范围: ALL Page页码 1 of 10 Completion Date(完成日期)： Job Card 工卡号： JC Title 工卡标题 EM000000600X52A00-1 EMB145 TRANSIT MAINTENANCE CHECKLIST EMB145飞机短停维护工作单 Mech 机械员 Insp 检验员 3. Check onboard spare oil quantity is no less than 4 quarts, spare hydraulic fluid is no less than ______ XXXXX 4 quarts. 检查随机备用滑油不少于4夸脱，备用液压油不少于4夸脱。 4. Check the crew oxygen pressure is 1100 psi 查看机组氧气压力在1100 psi 。 5. Check the engine oil level, and replenish as necessary 查看发动机的滑油量，并按需添加 6. Visually check the main door, service door and passenger cabin escape hatches are in good ______ XXXXX condition. 目视查看主舱门、服务门和客舱应急出口状态完好。 7. Walk around the aircraft to check for obvious damage of the aircraft and engine external surface. ______ XXXXX 绕飞机一周, 检查飞机和发动机外表无明显损坏。 A. Visual check the airplane exterior areas for no damage. 目视检查飞机整体的外部区域无损坏。 B. Perform a walk around to check the following items: 绕飞机一周，完成以下检查： NOTE: walk around the aircraft according to the set route,from the starting point back to the same location. The figure codes in the route diagram is the same as those of the step codes in the task card. The purpose is to remind the inspectors of its inspection key points. Inspectors should pay attention to any obvious damage in the skin and abnormal leakage in the drain holes, though they are not mentioned in the task card. And inspectors should check the wire pipes and proximity sensors for wear and damage. 注： 绕飞机一周必须按规定路线从起点开始，最后回到起点。绕机路线中的数字代码与工卡中的步骤顺序代码一致。目的是提醒检查者该处的检查重点。但是对于飞机外表蒙皮及遍布飞机的漏水孔，工卡虽未提及，检查者仍应注意蒙皮是否有明显的损坏，漏水孔是否有不正常的液体漏出，对飞机外部可见的导线管及邻近电门等电气部件，检查时也应注意是否有磨损或损坏。 (1) Fuselage forward section & nose landing gear: 机身前段和前起落架： ______ XXXXX Aircraft Effectivity飞机适用范围: ALL Page页码 2 of 10 Job Card 工卡号： JC Title 工卡标题 EM000000600X52A00-1 EMB145 TRANSIT MAINTENANCE CHECKLIST EMB145飞机短停维护工作单 Mech 机械员 Insp 检验员 (a) Visual inspect the radome and ensure the radome in good shape without damage (check the attached screws for loss and looseness). 目视检查雷达罩，确保外观正常，没有受损(固定螺栓没有明显的松动和丢失)。 (b) Visually check nose landing gear and spring cartridges for condition and shock absorber extension 目视检查前起落架和弹簧筒，以及减震支柱的伸出状况 (c) Visually inspect NLG tires for wear and general condition 目视检查前起落架轮胎的磨损情况 (d) Visually inspect NLG wheel assembly . 目视检查前起落架轮子组件的状况 。 (e) Visually inspect the NLG spin brake for general condition. 目视检查前起落架刹车片的状况。 (f) Visually check the following light assembly and make sure they are in good condition: nose landing lights; taxi lights. 检查下面的灯组件，确保状态完好：前着陆灯、滑行灯。 (g) Visually check crew oxygen cylinder pressure relief disc in a good condition 目视查看机组氧气瓶压力释压片完好 (h) Visual inspect VHF top/bottom antenna (2 in total). 目视检查VHF上天线（1个）；VHF下天线（1个）。 (i) Visual inspect VHF -3 top bottom antenna (1). 目视检查VHF -3上天线 (j) Visual inspect static discharger locating at the landing gear (1 in total). 目视检查前起落架区域下的放电刷（共1个）。 (k) Visual inspect TAT sensor (2 in total), PITOT/STATIC sensor. 目视检查TAT探头（2个），动/静压探头（1个）。 (l) Visual inspect left/right pitot sensor (1 on each side), left/right static sensor (1 on each side). 目视检查左右动压探头（各1个），左右静压孔（各2个）。 (m) Visual inspect MB antenna (2 in total). Aircraft Effectivity飞机适用范围: ALL Page页码 3 of 10 Job Card 工卡号： JC Title 工卡标题 EM000000600X52A00-1 EMB145 TRANSIT MAINTENANCE CHECKLIST EMB145飞机短停维护工作单 Mech 机械员 Insp 检验员 目视检查MB天线（2个）。 (n) Visual inspect TCAS low antenna. 目视检查TCAS下天线。 (o) Visual inspect DME antenna (2 in total). 目视检查DME天线（2个）。 (p) Visual inspect bottom transponder antenna of ATC. 目视检查ATC收发机下天线。 (2) Fuselage & wing center sections: 机身和大翼中段： (a) Visually check the anti-collision light assemblies (red) on the lower and upper part of fuselage and make sure they are in good condition. 目视检查下和上机身的防撞灯组件（红色），确保状态完好。 (b) Visually check fuel line shroud drains for absence of fuel leakage 目视查看燃油管套管余油口无燃油渗漏 (3) Wing & main landing section (RH): XXXXX 大翼和主起落架（右侧）： (a) Visually check the following light assembly and make sure they are in good condition: right landing lights and right inspection lights. 检查下面的灯组件，确保状态完好：右着陆灯和右大翼照明灯。 (b) Visually check the r wing leading，flight control surfaces on the r wing for no obvious damage or dent. 目视查看右大翼前缘、右大翼飞行控制舵面无明显损坏、无凹坑。 (c) Visual inspect r aileron PCA rod ends/fitting lugs for integrity and general condition 目视查看右副翼PCA杆端/接耳的连接完整情况 NOTE: for aircraft equipped with PCA P/N 394900-1007 注： Aircraft Effectivity飞机适用范围: ALL Page页码 4 of 10 ______ XXXXX ______ 安装了件号是：394900-1007的PCA Job Card 工卡号： JC Title 工卡标题 EM000000600X52A00-1 EMB145 TRANSIT MAINTENANCE CHECKLIST EMB145飞机短停维护工作单 Mech 机械员 Insp 检验员 (d) Visually check R under wing surfaces, tank access panels, dump valves and drain valves for absence of fuel leakage 目视查看右大翼下表面的燃油箱接近盖板和放水活门以及放油活门处没有漏油现象 (e) Visually check R main landing gear, including doors and spring cartridges 目视查看右主起落架，包括舱门和弹簧筒 (f) Visually check r MLG shock absorber extension 目视查看右主起落架减震支柱的伸出状况 。 (g) Visually inspect r MLG tires for wear and general condition 目视检查右主起落架轮胎的磨损情况 (h) Visually inspect r MLG wheel assembly 目视检查右主起落架轮子组件的状况 (i) Visually inspect the r MLG brake assembly for general condition . Visually check the wear indication pin for the brake assembly 目视检查右主起落架刹车组件的状况，以及查看刹车磨损指示销的长度。 (j) Check the under side of the R wing for no obviously damage or dent. There is not liquid in sign. 右机翼下表面无明显损坏和无凹坑，没有油液渗漏。 (k) Visually check the following light assembly on right wing and make sure they are in good condition: navigation lights and anti-collision lights. 检查右大翼上面的灯组件，确保状态完好：航行灯和防撞灯。 (l) Visual inspect static dischargers locating at the right wing tip area (5); 目视检查右大翼尖区域的放电刷（5个）； (4) Nacelle section (RH): 吊舱（右侧）： (a) Inspect right engine nose cowl, spinner, fan blades, cowl panels exhaust pipe, cone, and visible turbine blades for no damage. Check areas under the drain, cowls engine pylon drain tubes for no leakage. 检查右发动机进气道、锥、风扇叶片、包皮、排气管和可见的涡轮叶片无损坏，余油管无漏油。 (5) Vertical/horizontal stabilizer and tail: XXXXX Aircraft Effectivity飞机适用范围: ALL Page页码 5 of 10 ______ XXXXX ______