OEC-F OTIS ENGINEERING CENTRE - FARMINGTON Barry Blackaby GeN2: Hoistway/Position Access 进出井道/轿顶程序 FAA29100B_FM2_CARACC OtisA United Technologies Company PAGES: 7, 9/20/00 28
29
Verify the car responds to calls
检验电梯正确地响应呼梯 信号
Turn off hoistway lights and take REM off of service 关闭井道照明关闭REM系统
Rev Changed to add hoistway protection and doc control BB Added REM BB 2/16/00 Clarified repair height step 20B BB
1/19/00 Changed to activate the stop switch in step 10 to accommodate the new
rescue portion of hoistway intrusion detection BB
7/14/00 Edited Title BB 9/20/00 Removed preliminary reference. BB
12
OEC-F OTIS ENGINEERING CENTER - FARMINGTON H. Terry
GeN2: Fireman’s Access to Controller or Machine 接近控制柜或曳引机 FAA29100B_FM2_FIREACC OtisA United Technologies Company PAGES: 4, 5/12/00 Introduction:
This document details the steps required for a fireman to gain access to the top of car (TOC) for visual inspection of the controller or machine. 简介
本文介绍如何按照步骤要求进入轿顶查看控制柜或曳引机
POSITION ACCESS 进入轿顶
TASK # 工序
TASK DESCRIPTION
工序描述
TOOLING 工具
COMMENT
说明
1
Notify the appropriate building personnel that the car will be removed from service.
通知业主电梯将停止服务
2
3
4
Turn on hoistway lights and push the REM service button. 打开井道照明按下REM系统服务按钮
Press hall call to obtain the car.
按外呼截获电梯
Ensure no passengers are in the car.
确定没有乘客在轿箱内
Hoistway light switch and REM service in E&I panel 井道照明开关和REM服务开关在E&I操控盘上
13
OEC-F OTIS ENGINEERING CENTER - FARMINGTON H. Terry GeN2: Fireman’s Access to Controller or Machine 接近控制柜或曳引机 FAA29100B_FM2_FIREACC OtisA United Technologies Company PAGES: 4, 5/12/00 5
6
7
8
9
10
11
12
Register 2 car calls to lower floors.
设置所处楼层仅下方2个相邻楼层的内选按钮
Trip the hoistway door lock with the hoistway door key, allowing easy access to the top of car.
用厅门锁匙打开厅门确保可以轻松进入轿顶
Make sure the car stops 确认电梯停车不动
Activate the stop switch. 关闭急停开关
Access TOC, and close the Door
进入轿顶关闭厅门
Put the car on inspection 将电梯设置为检修状态
Pull out the stop switch. 拉出急停开关
Drive the car up until the TOC is .7 meters above the top landing
上行轿箱直到轿顶高于顶层0.7米的位置
14
OEC-F OTIS ENGINEERING CENTER - FARMINGTON H. Terry GeN2: Fireman’s Access to Controller or Machine 接近控制柜或曳引机 FAA29100B_FM2_FIREACC OtisA United Technologies Company PAGES: 4, 5/12/00 13
14
Activate the stop switch 关闭急停开关
Perform inspection 进行检修作业
TOC Exit Procedure 退出轿顶
15
Pull out the stop switch. 拉出急停开关
Drive TOC down to just above floor level, and comfortably open the door lock
下行轿箱直到轿顶略高于楼层位置可轻松开启门锁
Activate the stop switch 关闭急停开关
Open the hoistway door, exit TOC
打开厅门退出轿顶
Take car off of inspection 关闭检修模式
16
17
18
19
15
OEC-F OTIS ENGINEERING CENTER - FARMINGTON H. Terry GeN2: Fireman’s Access to Controller or Machine 接近控制柜或曳引机 FAA29100B_FM2_FIREACC OtisA United Technologies Company PAGES: 4, 5/12/00 20
21
22
23
Make up stop switch
拉出急停开关
Close hoistway door
关闭厅门
Verify the car responds to calls 检验电梯是否正确响应呼梯信号
Turn off hoistway lights and take REM off of service
关闭井道照明关闭REM服务系统
Car will do a correction run 电梯将寻址运行
16